A Novel Asymmetric Check Microvalve for Suppressing Flow Boiling Instability in Microchannels

  • ZHOU Fan ,
  • ZHAO Yang ,
  • YIN Ershuai ,
  • HU Dinghua ,
  • LI Qiang
Expand
  • MIIT Key Laboratory of Thermal Control of Electronic Equipment, School of Energy and Power Engineering, Nanjing University of Science and Technology, Nanjing 210094, China

Online published: 2024-11-05

Supported by

The authors acknowledge the financial support from the National Natural Science Foundation of China with Grant No. 52276070 and the Fundamental Research Funds for the Central Universities with Grant No. 30922010903.

Copyright

Science Press, Institute of Engineering Thermophysics, CAS and Springer-Verlag GmbH Germany, part of Springer Nature 2024

Abstract

Flow boiling in microchannels has attracted wide attention due to its excellent heat transfer capability, but flow boiling instability is a huge challenge limiting its application. Instability can lead to a series of problems, such as uneven flow distribution, temperature and pressure drop oscillations. This work proposes a novel asymmetric check microvalve (ACMV) structure, exhibiting high ratio of resistance between the reverse and forward flow. The results show the reverse pressure drop of the ACMV structure is 2.06 times that of the forward pressure drop, and the forward flow resistance of the ACMV structure is 16% smaller than that of the conventional inlet restrictor. In addition, bubble dynamics of an isolated bubble in the generated channel under dual outlet condition was numerically investigated. It is found that the bubble grows symmetrically in the rectangular channel upstream and downstream. The distance of bubble movement downstream in the microchannel with ACMV is three times that of the microchannel with inlet restrictor. The microchannel with ACMV can suppress the backflow of isolated bubble better than microchannel with inlet restrictor. Moreover, the growth of the bubble downstream extends the effective evaporation domain, which contributes to the enhanced bubble growth rate. The ACMV is expected to be a potential replacement for the conventional inlet restrictor, which provides a novel and efficient solution for future heat dissipation from high power devices.

Cite this article

ZHOU Fan , ZHAO Yang , YIN Ershuai , HU Dinghua , LI Qiang . A Novel Asymmetric Check Microvalve for Suppressing Flow Boiling Instability in Microchannels[J]. Journal of Thermal Science, 2024 , 33(6) : 2336 -2347 . DOI: 10.1007/s11630-024-2058-1

References

[1] He Z., Yan Y., Zhang Z., Thermal management and temperature uniformity enhancement of electronic devices by micro heat sinks: A review. Energy, 2021, 216: 119223. 
[2] Ding B., Zhang Z.H., Gong L., et al., A novel thermal management scheme for 3D-IC chips with multi-cores and high power density. Applied Thermal Engineering, 2020, 168: 114832. 
[3] Deng D., Zeng L., Sun W., A review on flow boiling enhancement and fabrication of enhanced microchannels of microchannel heat sinks. International Journal of Heat and Mass Transfer, 2021, 175: 121332.
[4] Prajapati Y.K., Bhandari P., Flow boiling instabilities in microchannels and their promising solutions – A review. Experimental Thermal and Fluid Science, 2017, 88: 576–593. 
[5] Zhang T., Peles Y., Wen J.T., et al., Analysis and active control of pressure-drop flow instabilities in boiling microchannel systems. International Journal of Heat and Mass Transfer, 2010, 53: 2347–2360.
[6] Barber J., Brutin D., Sefiane K., et al., Bubble confinement in flow boiling of FC-72 in a “rectangular” microchannel of high aspect ratio. Experimental Thermal and Fluid Science, 2010, 34: 1375–1388. 
[7] Lee H.J., Liu D.Y., Yao S., Flow instability of evaporative micro-channels. International Journal of Heat and Mass Transfer, 2010, 53: 1740–1749.
[8] Xu D., Fang Y., Zhang Z., et al., Experimental investigation on flow boiling instability of R1233zd(E) in a parallel mini-channel heat sink for the application of battery thermal management. International Journal of Heat and Mass Transfer, 2022, 188: 122585.
[9] Liu G., Xu J., Yang Y., et al., Active control of flow and heat transfer in silicon microchannels. Journal of Micromechanics and Microengineering, 2010, 20(4): 045006.
[10] Han Y., Shikazono N., Stabilization of flow boiling in a micro tube with air injection. Experimental Thermal and Fluid Science, 2011, 35(7): 1255–1264.
[11] Mukherjee A., Kandlikar S.G., The effect of inlet constriction on bubble growth during flow boiling in microchannels. International Journal of Heat and Mass Transfer, 2009, 52(21–22): 5204–5212.
[12] Wang G., Cheng P., Bergles A.E., Effects of inlet/outlet configurations on flow boiling instability in parallel microchannels. International Journal of Heat and Mass Transfer, 2008, 51(9–10): 2267–2281.
[13] Szczukiewicz S., Borhani N., Thome J.R., Two-phase flow operational maps for multi-microchannel evaporators. International Journal of Heat and Fluid Flow, 2013, 42: 176–189.
[14] Lee P.C., Pan C., Boiling heat transfer and two-phase flow of water in a single shallow microchannel with a uniform or diverging cross section. Journal of Micromechanics and Microengineering, 2007, 18(2): 025005.
[15] Wang H.L., Wu H.C., Wang S.K., et al., A study of mini-channel thermal module design for achieving high stability and high capability in electronic cooling. Applied Thermal Engineering, 2013, 51(1–2): 1144– 1153.
[16] Zhang T.J., Wen J.T., Peles Y., et al., Two-phase refrigerant flow instability analysis and active control in transient electronics cooling systems. International Journal of Multiphase Flow, 2011, 37(1): 84–97.
[17] Lu C.T., Pan C., Convective boiling in a parallel microchannel heat sink with a diverging cross section and artificial nucleation sites. Experimental Thermal and Fluid Science, 2011, 35(5): 810–815.
[18] Wang J., Desideri U., Liu X., Multi-objective structure optimization and performance analysis of catalytic micro-reactor channel designed by an improved topology optimization model. Applied Thermal Engineering, 2024: 122742.
[19] Mo X., Zhi H., Xiao Y., et al., Topology optimization of cooling plates for battery thermal management. International Journal of Heat and Fluid Flow, 2021, 178: 121612.
[20] Yan S., Wang F., Hong J., et al., Topology optimization of microchannel heat sinks using a two-layer model. International Journal of Heat and Fluid Flow, 2019, 143: 118462.
[21] Zhou J., Lu M., Zhao Q., et al., Thermal design of microchannel heat sinks using a contour extraction based on topology optimization (CEBTO) method. International Journal of Heat and Fluid Flow, 2022, 189: 122703.
[22] Ho J.Y., See Y.S., Leong K.C., et al., An experimental investigation of a PCM-based heat sink enhanced with a topology-optimized tree-like structure. Energy Conversion and Management, 2021, 245: 114608.
[23] Olesen L.H., Okkels F., Bruus H., A high-level programming-language implementation of topology optimization applied to steady-state Navier-Stokes flow. International Journal for Numerical Methods in Engineering, 2006, 65(7): 975–1001.
[24] Bianco N., Cherella N., Fragnito A., et al., Multi-material topology optimization of innovative microchannel heat sinks equipped with metal foams. International Journal of Heat and Mass Transfer, 2024, 222: 125201.
[25] Li H., Ding X., Meng F., et al., Optimal design and thermal modelling for liquid-cooled heat sink based on multi-objective topology optimization: An experimental and numerical study. International Journal of Heat and Mass Transfer, 2019, 144: 118638
[26] Okkels F., Bruus H., Scaling behavior of optimally structured catalytic microfluidic reactors. Physical Review E—Statistical, Nonlinear, and Soft Matter Physics, 2007, 75(1): 016301.
[27] Zhang B., Zhu J., Gao L., Topology optimization design of nanofluid-cooled microchannel heat sink with temperature-dependent fluid properties. Applied Thermal Engineering, 2020, 176: 115354.
[28] Lazarov B.S., Sigmund O., Filters in topology optimization based on Helmholtz-type differential equations. International Journal for Numerical Methods in Engineering, 2011, 86(6): 765–781.
[29] Wang F., Lazarov B.S., Sigmund O., On projection methods, convergence and robust formulations in topology optimization. Structural and Multidisciplinary Optimization, 2011, 43: 767–784.
[30] Mukherjee A., Kandlikar S.G., Numerical study of the effect of inlet constriction on bubble growth during flow boiling in microchannels. International Conference on Nanochannels, Microchannels, and Minichannels, 2005, 41855: 73–80.
[31] Zhou J.H., Li Q., Chen X.M., Micro pin fins with topologically optimized configurations enhance flow boiling heat transfer in manifold microchannel heat sinks. International Journal of Heat and Mass Transfer, 2023, 206: 123956.
[32] Vargaftik N.B., Volkov B.N., Voljak L.D., International tables of the surface tension of water. Journal of Physical and Chemical Reference Data, 1983, 12(3): 817–820.
[33] Sun D.L., Xu J.L., Wang L., Development of a vapor-liquid phase change model for volume-of-fluid method in FLUENT. International Journal of Heat and Mass Transfer, 2012, 39(8): 1101–1106
[34] Cao Z., Zhou J., Wei J., et al., Direct numerical simulation of bubble dynamics and heat transfer during nucleate boiling on the micro-pin-finned surfaces Keywords Two-phase flow VOSET Micro-pin-fin Pool boiling. International Journal of Heat and Mass Transfer, 2020, 163: 120504.
[35] Mukherjee A., Kandlikar S.G., Numerical simulation of growth of a vapor bubble during flow boiling of water in a microchannel. Microfluidics & Nanofluidics, 2005, 1(2): 137–145.
[36] Mukherjee A., Kandlikar S.G., Edel Z.J., Numerical study of bubble growth and wall heat transfer during flow boiling in a microchannel. International Journal of Heat and Mass Transfer, 2011, 54(15–16): 3702–3718.
Outlines

/