Heat and mass transfer

Transient Behaviors of Thermo-Hydraulic and Thermal Stratification in the Pressurizer Surgeline for the Nuclear Power Plant

  • YU Huajie ,
  • LI Lu ,
  • TANG Qionghui ,
  • PENG Yue ,
  • LI Yinshi
Expand
  • 1. State Key Laboratory of Nuclear Power Safety Monitoring Technology and Equipment, Shenzhen 518172, China
    2. Key Laboratory of Thermo-Fluid Science and Engineering of Ministry of Education, School of Energy and Power Engineering, Xi’an Jiaotong University, Xi’an 710049, China
    3. School of Mechanics and Safety Engineering, Zhengzhou University, Zhengzhou 450001, China

Online published: 2023-11-30

Supported by

This work was supported by the Open Project of State Key Laboratory of Nuclear Power Safety Monitoring Technology and Equipment (K-A2019.424).

Copyright

Science Press, Institute of Engineering Thermophysics, CAS and Springer-Verlag GmbH Germany, part of Springer Nature 2022

Abstract

In pressurized water reactor (PWR) system, the surgeline plays an important role in bonding the pressurizer and the primary circle. Some considerable problems, including the thermo-hydraulics, the thermal stratification and the accompanying thermal stress under transient conditions, pose risks to the surgeline integrity. Herein, a fully-coupled flow-heat-thermo-elasticity model was developed to investigate the transient behavior of thermo-hydraulic parameters and the thermal stratification phenomenon in PWR. To evaluate the nonuniformity of the stratified flow, a stratification degree indicator ζ is introduced. It is found that during the outsurge flow, the increase of temperature variation will enlarge the temperature gradient on the wall, corresponding to a more serious deformation. In the cases of positive temperature variation, the higher temperature variation causes higher stratification degree ζ, and vice versa. The mass flow rate   and the stratification degree are in negative correlation. The local deformation can reach 1.802 cm under a 50 K temperature variation, while its location varies from case to case. More attention should be paid to the regulation between the highest deformation location and the surgeline thermo-hydraulic parameters.

Cite this article

YU Huajie , LI Lu , TANG Qionghui , PENG Yue , LI Yinshi . Transient Behaviors of Thermo-Hydraulic and Thermal Stratification in the Pressurizer Surgeline for the Nuclear Power Plant[J]. Journal of Thermal Science, 2022 , 31(2) : 344 -358 . DOI: 10.1007/s11630-022-1536-6

References

[1] Cracking in feedwater system piping (Bulletin 79–13). Nuclear Regulatory Commission (NRC), US, 1979.
[2] Thermal stresses in piping connected to reactor coolant systems (Bulletin 88–08). Nuclear Regulatory Commission (NRC), US, 1988.
[3] Pressurizer surge line thermal stratification (Bulletin 88–11). Nuclear Regulatory Commission (NRC), US, 1988.
[4] Review of industry efforts to manage pressurized water reactor feedwater nozzle, piping, and feedering cracking and wall thinning (Report No. 6456). Nuclear Regulatory Commission (NRC), US, 1989.
[5] Kim S.N., Hwang S.H., Yoon K.H., Experiments on the thermal stratification in the branch of NPP. Journal of Mechanical Science and Technology, 2005, 19(5): 1206–1215.
[6] Da Silva L.L., Mansur T.R., Junior C.A.C., Thermal fatigue damage evaluation of a PWR NPP steam generator injection nozzle model subjected to thermal stratification phenomenon. Nuclear Engineering and Design, 2011, 241(3): 672–680.
[7] Qiao S., Gu H., Wang H., et al., Experimental investigation of thermal stratification in a pressurizer surge line. Annals of Nuclear Energy, 2014, 73: 211–217.
[8] Cai B., Weng Y., Wang Y., et al., Experimental investigation on thermal stratification in a pressurizer surge line with different arrangements. Progress in Nuclear Energy, 2017, 98: 239–247.
[9] Yu Y.J., Park S.H., Sohn G.H., et al., Structural evaluation of thermal stratification for PWR surge line. Nuclear Engineering and Design, 1997, 178(2): 211–220. 
[10] Ensel C., Colas A., Barthez M., Stress analysis of a 900 MW pressurizer surge line including stratification effects. Nuclear Engineering and Design, 1995, 153(2–3): 197–203.
[11] Xia Z., Lu D., Tang J., et al., Three-dimensional thermal hydraulic transient calculation of coupled cold and hot sodium pools under a loss of feedwater accident in the China experimental fast reactor. Annals of Nuclear Energy, 2020, 139: 107217.
[12] Mochizuki H., Yao H., Analysis of thermal stratification in the upper plenum of the “Monju” reactor. Nuclear Engineering and Design, 2014, 270: 48–59.
[13] Jo J.C., Kim Y.I., Choi S.K., Numerical analysis of thermal stratification in a circular pipe. Journal of Pressure Vessel Technology, 2001, 123(4): 517–524.
[14] Jo J.C., Choi Y.H., Choi S.K., Numerical analysis of unsteady conjugate heat transfer and thermal stress for a curved piping system subjected to thermal stratification. Journal of Pressure Vessel Technology, 2003, 125(4): 467–474.
[15] Jo J.C., Kim S.J., Choi Y.H., et al., Transient response of thermal stress at a PWR pressurizer surge line pipe subjected to internally thermal stratification. Proceedings of the Korean Nuclear Society Autumn Meeting, Yongpyong, Korea, 2002, 1–10.
[16] Jo J.C., Kang D.G., CFD analysis of thermally stratified flow and conjugate heat transfer in a PWR pressurizer surgeline. Journal of Pressure Vessel Technology, 2010, 132(2): 021321. 
[17] Kang D.G., Jhung M.J., Chang S.H., Fluid-structure interaction analysis for pressurizer surge line subjected to thermal stratification. Nuclear Engineering and Design, 2011, 241(1): 257–269.
[18] Jo J.C., Jeong J.J., Yun B.J., et al., Numerical prediction of transient hydraulic loads acting on PWR steam generator tubes and supports during blowdown following a feedwater line break. Nuclear Engineering and Technology, 2021, 53(1): 322–336.
[19] Wang M., Feng T., Fang D., et al., Numerical study on the thermal stratification characteristics of AP1000 pressurizer surge line. Annals of Nuclear Energy, 2019, 130: 8–19.
[20] Zimoń M.J., Skillen A., Liu W., et al., Surrogate modelling of transient stratified flow in a u-shaped pipe. Nuclear Engineering and Design, 2020, 368: 110787.
[21] Utanohara Y., Nakamura A., Miyoshi K., et al., Numerical simulation of long-period fluid temperature fluctuation at a mixing tee for the thermal fatigue problem. Nuclear Engineering and Design, 2016, 305: 639–652.
[22] Cizelj L., Simonovski I., Fatigue relevance of stratified flows in pipes: A parametric study. Nuclear Engineering and Design, 2011, 241(4): 1191–1195.
[23] Kim S.H., Choi J.B., Park J.S., et al., A coupled CFD-FEM analysis on the safety injection piping subjected to thermal stratification. Nuclear Engineering and Technology, 2013, 45(2): 237–248.
[24] Kumar R., Jadhav P.A., Gupta S.K., et al., Evaluation of thermal stratification induced stress in pipe and its impact on fatigue design. Procedia Engineering, 2014, 86: 342–349.
[25] Jhung M.J., Choi Y.H., Stress analysis of surge line due to thermal stratification. Nuclear Engineering and Technology, 2008, 40(3): 239–250.
[26] Do Kweon H., Kim J.S., Lee K.Y., Fatigue design of nuclear class 1 piping considering thermal stratification. Nuclear Engineering and Design, 2008, 238(6): 1265–1274.
[27] Zhang Y., Lu T., Jiang P.X., et al., Investigation on thermal stratification and turbulent penetration in a pressurizer surge line with an overall out-surge flow. Annals of Nuclear Energy, 2016, 90: 212–233.
[28] Zhang Y., Lu T., Unsteady-state thermal stress and thermal deformation analysis for a pressurizer surge line subjected to thermal stratification based on a coupled CFD-FEM method. Annals of Nuclear Energy, 2017, 108: 253–267.
[29] Cai B., Gu H., Weng Y., et al., Numerical investigation on the thermal stratification in a pressurizer surge line. Annals of Nuclear Energy, 2017, 101: 293–300.
[30] Tang P., Luo J.C., Sun L., et al., Fatigue crack growth analysis of surge line under thermal stratification conditions. IOP Conference Series: Materials Science and Engineering, 2019, 629(1): 012018.
[31] Kim J.S., Kim J.Y., Simplified elastic-plastic analysis procedure for strain-based fatigue assessment of nuclear safety class 1 components under severe seismic loads. Nuclear Engineering and Technology, 2020, 52(12): 2918–2927.
[32] Menter F.R., Two-equation eddy-viscosity turbulence models for engineering applications. AIAA journal, 1994, 32(8): 1598–1605.
[33] ANSYS FLUENT theory guide. Inc. Southpointe 2600 ANSYS Drive Canonsburg, PA, 2011.
[34] Li L., Yu H.J., Li Y.S., et al., Characteristics of the transient thermal load and deformation of the evacuated receiver in solar parabolic trough collector. Science China Technological Sciences, 2020, 63: 1188–1201. 
[35] Eslami M.R., Hetnarski R.B., Ignaczak J., et al., Theory of elasticity and thermal stresses. Dordrecht: Springer, 2013.

Outlines

/